Abstract
Fish oils are rich source of omega-3 long chain polyunsaturated fatty acids with several health benefits but their application in food products is a challenge due to strong odor and widespread oxidation. Thus, the object of this study was to produce nano-encapsulated fish oil in nano-liposomes to investigate the effect of the addition of 0.0 (control), and 5% (w/w) nano-encapsulated fish oil on the technological and sensory quality of fortified bread. Physical properties and oxidative stability of fish oil nano-liposomes at 25 days in refrigerated condition were determined. The nano-capsules were characterized by their encapsulation efficiency and particle size distributions. Our results revealed a particle size of about 339.2 nm and a Polydispersity Index of 0.426. The nano-encapsulation efficiency of fish oil incorporated in nano-liposomes was measured as 90.12 ± 0.27%. Nano-encapsulated fish oil showed a better oxidative stability against lipid oxidation in comparison with free (unencapsulated) fish oil. The technological and sensory evaluation indicated that enriched bread with nano-liposomal fish oil had a higher loaf volume of bread than other samples. The addition of nano-liposomal fish oil had no negative effect on bread textural quality and sensory acceptability. So, using of nano-liposomal fish oil as an effective additive for improvement of the nutritional value of bread and its application is suggested for production of other bakery products.
Similar content being viewed by others
References
U. Klinkesorn, P. Sophanodora, P. Chinachoti, E.A. Decker, D.J. McClements, Characterization of spray-dried tuna oil emulsified in two-layered interfacial membranes prepared using electrostatic layer-by-layer deposition. Food. Res. Int. 39, 449–457 (2006)
Q. Chen, D. McGillivray, J. Wenb, F. Zhong, S. Young Quek, Co-encapsulation of fish oil with phytosterol esters and limonene by milk proteins. J. Food Eng. 117, 505–512 (2013)
W. Kolanowski, M. Ziolkowski, J. Weißbrodt, B. Kunz, G. Laufenberg, Microencapsulation of fish oil by spray drying-impact on oxidative stability: part 1. Eur. Food Res. Technol. 222(3–4), 336–342 (2006)
EFSA (European Food Safety Authority), Guidance of the Scientific Committee on a request from EFSA related to uncertainties in dietary exposure assessment (Question No EFSA-Q-2004-019). 438, 1–54 (2006). http://www.efsa.europa.eu/cs/BlobServer/Scientific_Opinion/sc_op_uncertainty%20exp_en.pdf?ssbinary=true>. Accessed 14 Dec 2006
S.M. Jafari, E. Assadpoor, B. Bhandari, Y. He, Nano-particle encapsulation of fish oil by spray drying. Food Res. Int. 41, 172–183 (2008)
J. Velasco, C. Dobarganes, F. Holgado, G. Márquez-Ruiz, A follow-up oxidation study in dried microencapsulated oils under the accelerated conditions of the Rancimat test. Food Res. Int. 42, 56–62 (2009)
A.A. Motalebi, M. Seyfzadeh, Effects of whey protein edible coating on bacterial, chemical and sensory characteristics of frozen common Kilka (Clupeonellia delitula). Iran. J. Fish. Sci. 11(1)), 132–144 (2015)
H.C.F. Carneiro, R.V. Tonon, C.R.F. Grosso, M.D. Hubinger, Encapsulation efficiency and oxidative stability of flaxseed oil microencapsulated by spray drying using different combinations of wall materials. J. Food Eng. 115, 443–451 (2013)
M. Hasani, A.H. Elhami Rad, M. Mohammad Hosseini, M.S. Noghabi, Physicochemical characteristic of microencapsulated fish oil by freeze-drying using different combinations of wall materials. Biosci. Biotechnol. Res. Asia 12, 45–51 (2015)
A. Munin, F. Edwards-Lévy, Encapsulation of natural polyphenolic compounds: a review. Pharmaceutics 3(4), 793–829 (2011)
T. Ghorbanzade, S.M. Jafari, S. Akhavan, R. Hadavi, Nano-encapsulation of fish oil in nano-liposomes and its application in fortification of yogurt. Food Chem. 216, 146–152 (2017)
M.R. Mozafari, K. Khosravi-Darani, G.G. Borazan, J. Cui, A. Pardakhty, S. Yurdugul, Encapsulation of food ingredients using nanoliposome technology. Int. J. Food Prop. 11(4), 833–844 (2008)
G. Gallardo, L. Guida, V. Martínez, M.C. López, D. Bernhardt, R. Blasco, R. Pedroza-Islas, L.G. Hermida, Microencapsulation of linseed oil by spray drying for functional food application. Food Res. Int. 52(2), 473–482 (2013)
S. Takeungwongtrakul, S. Benjakul, H. Aran, Characteristics and oxidative stability of bread fortified with encapsulated shrimp oil. Ital. J. Food Sci. 117, 450–459 (2016)
S.A. Hogan, B.F.D. McNamee, E. O’Riordan, M. O’Sullivan, Emulsification and microencapsulation properties of sodium caseinate/carbohydrate blends. Int. Dairy J. 11, 137–144 (2001)
W. Klaypradit, Y.W. Huang, Fish oil encapsulation with chitosan using ultrasonic atomizer. LWT-Food Sci. Technol. 41(6), 1133–1139 (2008)
S. Anwar, B. Kunz, The influence of drying methods on the stabilization of fish oil microcapsules: comparison of spray granulation, spray drying and freeze drying. J. Food Eng. 105, 367–378 (2011)
B. Rasti, S. Jinap, M. Mozafari, A. Yazid, Comparative study of the oxidative and physical stability of liposomal and nanoliposomal polyunsaturated fatty acids prepared with conventional and Mozafari methods. Food Chem. 135(4), 2761–2770 (2012)
M. Maleki, J.L. Vetter, W.J. Hover, The effect of emulsifiers, sugar, shortening and soya flour on the staling of barbari flat bread. J. Sci. Food Agric. 32, 1209–1211 (1981)
C. Gomes, R.G. Moreira, E. Castell-Perez, Microencapsulated antimicrobial compounds as a means to enhance electron beam irradiation treatment for inactivation of pathogens on fresh spinach leaves. J. Food Sci. 76(6), 479–488 (2011)
Association of Official Analytical Chemists (AOAC), Official Methods of Analysis, 15th edn. (AOAC, Arlington, 1996)
R. Mcdonald, H. Hultin, Some characteristics of the enzymic lipid peroxidation system in the microsomal fraction of flounder skeletal muscle. J. Food Sci. 52(1)), 15–21 (1987)
American Association of Cereal Chemists (AACC), Approved Methods of the Cereal Chemists, 10th edn. (AACC, 2000)
V. Gökmen, B.A. Mogol, R.B. Lumaga, V. Fogliano, Z. Kaplun, E. Shimoni, Development of functional bread containing nanoencapsulated omega-3 fatty acids. J. Food. Eng. 105, 585–591 (2011)
W. Jiang, R. Lionberger, L.X. Yu, In vitro and in vivo characterizations of PEGylated liposomal doxorubicin. Bioanalysis. 3(3), 333–344 (2011)
L.Q. Zou, W. Liu, W.L. Liu, R.H. Liang, T. Li, C.M. Liu, Z. Liu, Characterization and bioavailability of tea polyphenol nanoliposome prepared by combining an ethanol injection method with dynamic high-pressure microfluidization. J. Agric. Food Chem. 62(4), 934–941 (2014)
N. Liu, H.J. Park, Chitosan-coated nanoliposome as vitamin E carrier. J. Microencapsul. 26(3), 235–242 (2009)
H. Cui, W. Li, C. Li, S. Vittayapadung, L. Lin, Liposome containing cinnamon oil with antibacterial activity against methicillin-resistant Staphylococcus aureus biofilm. Biofouling. 32(2), 215–225 (2016)
B. Öztürk, Nanoemulsions for food fortification with lipophilic vitamins: production challenges, stability, and bioavailability. Eur. J. Lipid Sci. Technol. 119, 1–18 (2017)
Q. Lu, P.M. Lu, J.H. Piao, X.L. Xu, J. Chen, L. Zhu, J.G. Jiang, Preparation and physicochemical characteristics of an allicin nanoliposome and its release behavior. LWT-Food Sci. Technol. 57(2), 686–695 (2014)
E. Elizondo, J. Larsen, N.S. Hatzakis, I. Cabrera, T. Bjørnholm, J. Veciana, N. Ventosa, Influence of the preparation route on the supramolecular organization of lipids in a vesicular system. J. Am. Chem. Soc.. 134(4), 1918–1921 (2012)
E. Nara, K. Miyashita, T. Ota, Oxidative stability of liposomes prepared from soybean PC, chicken egg PC, and salmon egg PC. Biosci. Biotechnol. Biochem. 61, 1736–1738 (1997)
N. Moussaoui, M. Cansell, A. Denizot, Marinosomes, marine lipid-based liposomes: physical characterization and potential application in cosmetics. Int J Pharmac. 242, 361–365 (2002)
A.M. Lyberg, E. Fasoli, P. Adlercreutz, Monitoring the oxidation of docosahexaenoic acid in lipids. Lipids. 40(9), 969–979 (2005)
F. Shahidi, U.N. Wanasundara, Chemistry, nutrition, and biotechnology, in Food Lipids, ed. by C.C. Akoh, D.B. Min (Marcel Dekker, Inc., New York, 2002), pp. 465–487
J. Tarek-Tilistyak, M. Tarek, M. Juhasz-Roman, Effect of oil-seed pressing residue on bread color and texture. Acta Univ. Sapientiae Alimentaria 8, 118–124 (2015)
M. Eduardo, U. Svanberg, L. Ahrne, Effect of hydrocolloids and emulsifiers on baking quality of composite cassava-maize-wheat breads. Int. J. Food Sci. 2014, 1–9 (2014)
S.O. Serna-Saldivar, R. Zorrilla, C. De La Parra, G. Stagnitti, R. Abril, Effect of DHA containing oils and powders on baking performance and quality of white pan bread. Plant Foods Hum. Nutr. 61, 121–129 (2006)
H. Singh, N. Singh, K. Kaur, Effects of additives and pH on dough development and gaseous release characteristics of sound and sprouted wheat. J. Food Sci. Technol. 35, 393–398 (1998)
N. Hesso, A. Le-Bail, C. Loisel, S. Chevallier, B. Pontoire, D. Queveau, P. Le-Bail, Monitoring the crystallization of starch and lipid components of the cake crumb during staling. Carbohyd. Polym. 133, 533–538 (2015)
O. Mentes, E. Bakkalbassi, R. Ercan, Effect of the use of ground flaxseed on quality and chemical composition of bread. Food Sci Tech Int. 14, 299–306 (2008)
T.A. Pohjanheimo, M.A. Hakala, R.L. Tahvonen, S.J. Salminen, H.P. Kallio, Flaxseed in breadmaking: effects on sensory quality, aging, and composition of bakery products. J. Food Sci. 71, 343–348 (2006)
P.N. Ezhilarasi, D. Indrani, B.S. Jena, C. Anandharamakrishnan, Microencapsulation of garcinia fruit extract by spray drying and its effect on bread quality. J. Sci. Food. Agric. 94, 1116–1123 (2014)
L.C. de Conto, R.S.P. Oliveira, L. Martin, Y. Chang, C. Steel, Effects of the addition of microencapsulated omega-3 and rosemary extract on the technological and sensory quality of white pan bread. LWT-Food Sci. Technol. 45, 103–109 (2012)
J.R. Rendon-Villalobos, L.A. Bello-Perez, E. Agama-Acevedo, J.J. Islas-Hernandez, P. Osorio-Diaz, J. Tovar, Composition and characteristics of oil extracted from flaxseed-added corn tortilla. Food Chem. 117, 83–87 (2009)
M. Nunes, L.A.M. Ryan, E. Arendt, Effect of low lactose dairy powder addition on the properties of gluten-free batters and bread quality. Eur. Food Res. Technol. 229, 31–41 (2009)
Funding
The funding was provided by Gorgan University of Agricultural Sciences and Natural Resources.
Author information
Authors and Affiliations
Corresponding author
Ethics declarations
Conflict of interest
The authors report no conflicts of interest.
Rights and permissions
About this article
Cite this article
Ojagh, S.M., Hasani, S. Characteristics and oxidative stability of fish oil nano-liposomes and its application in functional bread. Food Measure 12, 1084–1092 (2018). https://doi.org/10.1007/s11694-018-9724-5
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11694-018-9724-5